Transfer Valve
Valve installation profiles, valve installation and maintenance guide
SOLDERING AND SILVER BRAZING
¡¡¡¡Analyze the application to determine which valve is best suited for installations, keeping in mind the service for which the valve is recommended. Before installing the correct valve, review the installation instructions to prevent damage to the valve and to assure its maximum efficiency.
1.Cut tube end square. Ream, burr and size.
2. Use sand cloth or steel wire brush to clean both ends to a bright metal finish. Steel wool is notrecommended.
3. Apply flux to outside of tube and inside of solder cup. Surfaces to be joined must be completely covered. Use flux sparingly.
4.Be sure that valve is fully open. Apply heat to tube first. Transfer as much heat as possible through tube into valve. Avoid
prolonged heating of valve itself.
5.Silver Brazing Method: Assemble parts to be brazed. If fluxed parts are allowed to stand, the water in the flux will evaporate, and dried flux is liable to flake off, exposing metal surfaces to oxidation. Assemble joint by inserting tube into socket hard against the stop. The assembly should be firmly supported so that it will remain in alignment during the brazing operation.
¡¡¡¡NOTE: On one-inch and larger valves, it is difficult to bring the whole joint up to temperature at one time. It will frequently be found desirable to use a double-tip torch to maintain the proper temperature over the larger area. A mild pre-heating of the whole socket area is recommended. Apply heat to parts to be joined. The preferred method is by oxy-acetylene flame. Heat tube first, beginning one inch from edge of valve. Sweep flame around tube in short strokes up and down at right angles to run of tube. To avoid burning through tube, the flame should be in continuous motion and not allowed to remain on any one point.
Apply flame to valve at base of socket. Heat uniformly, sweeping flame from valve to tube until flux on valve becomes quiet. Avoid excessive heating of valve.
¡¡¡¡When flux appears liquid and transparent on both tube and valve, start sweeping flame back and forth along axis of joint to maintain heat on parts to be joined, especially toward base of valve socket.
6. Use just enough solder: with wire solder, use 3/4″ for a 3/4″ valve, etc. If too much solder is used, it may flow past tube stop and clog sealing area. When joint is filled, a continuous run of solder or brazing alloy will be visible.
7. Silver Brazing Method: Apply brazing wire or rod at point where tube enters valve socket. Keep flame away from rod or wire as it is fed into the joint. Move flame back and forth as alloy is drawn into joint. When the proper temperature is reached alloy will flow readily into space between tube outer wall and valve socket. When joint is filled, a continuous rim of brazing alloy will be visible.
8. Remove excess solder with small brush while plastic, leaving a fillet around end of valve as it cools.
SILVER BRAZING¡¡¡¡
¡¡¡¡The strength of a brazed joint does not vary appreciably with the different brazing materials, but depends to a large extent upon the maintenance of proper clearance between the outside of the tube and the valve socket. The interior dimensions of silver brazing valve sockets are machined to the closest tolerances and finished smooth to promote full capillary attraction.
¡¡¡¡NOTE: Care should be observed in cleaning and in removing residues of the cleaning medium. Attempting to braze a contaminated or improperly cleaned surface will result in an unsatisfactory joint. Silver brazing alloys will not flow over or bond to oxides. Oily or greasy surfaces repel fluxes, leaving bare spots which oxidize and result in voids and inclusions.
THREADING
¡¡Grit, dirt or any foreign matter accumulated in the pipe can hinder efficient valve operation and seriously damage vital valve parts. Thoroughly clean pipe internally with air or steam.
¡¡¡¡When threading pipe, gauge pipe threads for size and length to avoid jamming pipe against seat and disc. Thoroughly clean threaded end to remove any harmful steel or iron deposits. For a good joint, use teflon tape or pipe dope. If pipe dope is used, apply sparingly on pipe threads, neveron valve threads. Do not allow any pipe dope into valve body in order to avoid damage to disc and seat.
¡¡¡¡Before installation, check line of flow through valve so that valve will function properly. Close valve completely before installation. Apply wrench to hex next to pipe and guard against possible distortion. After installation of valve, support line; a sagging pipe line can distort valve and cause failure.
FLANGED
¡¡¡¡There are several steps to follow to make sure that a flanged joint will be properly assembled. First, clean the joint carefully. Then loosely assemble the joint by putting in the bottom two or three bolts. Then carefully insert the gasket into place. The bottom bolts will help locate the gasket and hold it in position. Then insert the rest of the bolts into place and tighten all of the bolts evenly-not in rotation, but by the cross-over method to load the bolts evenly and eliminate concentrated stresses. The bolts should be checked for tightness after an appropriate interval of use and retightened if nec .
All rights reserved by FBIC Inc., do remember to show the source (www.fsbic.com) of the news when copying
About the Author
FBIC Inc., a member of Siduona group in flow-control business, has over 15 year experience in manufacturing ball valve, gate valve, globe valve, check check valve, plug valve and butterfly valve in carbon steel, stainless steel Valve.
AXILLARY VEIN VALVE TRANSFER IN PATIENTS WITH CVI
|
|
Kohler K-409-K-NA Hand Shower Transfer Valve with Vacuum Breaker NIB $49.99 |
|
|
Bronze 1/2″ 2 Way 4 Port Tub Shower Diverter Transfer Valve Faucet & Trim Faucet $74.75 |
|
|
Kohler k-t10424-4s-BN Brushed Nickel Memoirs transfer valve trim with Stately $156.91 |
|
|
Kohler Master Shower 2-3 Way Transfer Valve K-728-K NIB $108.00 |
|
|
Moen T4111AZ Kingsley Moentrol with Transfer Valve Trim Only Antique Bronze $119.30 |
|
|
Kohler Polished Chrome Transfer Valve Trim Kit T10113-4 $249.95 |
|
|
Delta RP33791-LHP Victorian Roman Tub Handshower w/ Transfer Valve w/out Handle $219.00 |
|
|
Pinstripe Transfer Valve Trim $343.16 |
|
|
Kohler K-T10595-4-SN Transfer Valve Trim Nickel $131.61 |
|
|
Kohler K-T14491-4-BN Transfer Valve Trim Only Nickel $147.77 |
|
|
Kohler K-T14783-4-BN 3 Way Transfer Valve Trim Only $154.09 |
|
|
Kohler K-T10944-4-BN Stillness Transfer Valve Trim – Brushed Nickel $170.99 |
|
|
Kohler Memoirs Stately K-T10424-4S Transfer Shower Valve Trim Brushed Bronze $79.99 |
|
|
KOHLER K-T9518-7-PB MasterShower wall-mount 3-way transfer valve trim with cyli $278.90 |
|
|
Kohler Bath-mount transfer check valve K-408-K-NA $112.00 |
|
|
Delta RP14979PB Polished Brass Roman Tub Handshower with Transfer Valve $337.03 |
|
|
Kohler 59707 Part – Valve- Transfer With Vac Bkr Genuine Service Part New $39.99 |
|
|
Kohler K-T376-4-PB Transfer Valve Trim Brass $108.66 |
|
|
Kohler Finial Traditional Transfer Valve Trim $119.99 |
|
|
Grohe Rough Valve 29714 000 5 Port -Diverter / Transfer Valve – New $84.95 |
|
|
Moen T4111AN Kingsley Moentrol with Transfer Valve Trim Only Antique Nickel $131.24 |
|
|
Moen T4111WR Kingsley Moentrol with Transfer Valve Trim Only Wrought Iron $131.24 |
|
|
Speakman S-1182 Commander Chrome Plated Transfer Valve w/Lever Handle,NEWINBOX $50.00 |
|
|
Kohler 408-K-NA Bath-Mount Transfer Check Valve w/Vacuum Breaker $85.00 |
|
|
2 Way 1/2″ Bathtub Tub Bathroom Shower Diverter Transfer Valve Faucet Chrome $59.99 |
|
|
Kohler 728-K-NA Mastershower® 2- or 3-way Transfer Valve New~ $99.95 |
|
|
Kohler K-T13175-4B-CP Transfer Valve Trim Chrome $267.38 |
|
|
NIB MOEN MOENTROL #3330 3 FUNCTION TRANSFER VALVE 3 PORT CC W/STOPS $68.00 |
|
|
Delta RP14979 Chrome Roman Tub Handshower with Transfer Valve $263.49 |
|
|
MOEN Moentrol 3 Function Transfer Valve 3330 $157.72 |
|
|
Kohler Memoirs transfer valve trim K-T10424-4S-BV $96.00 |
|
|
Moen Monticello Three Function Transfer Valve Extension Kit 110317 $41.97 |
|
|
Delta RP14979 Roman Tub Deck Mounted Handshower & Transfer Valve – Chrome NIB $219.99 |
|
|
S Moen T4111AZ Three Function Volume Transfer Valve $115.99 |
|
|
New Kohler Mastershower 3 Way Transfer Valve Trim T9474-4-BV Brushed Bronze $99.95 |
|
|
Moen 3530 5 Function Transfer Valve Rough In Shower $59.99 |
|
|
Nickel 1/2″ 2 Way 4 Port Tub Shower Diverter Transfer Valve Faucet & Trim $69.75 |
|
|
Kohler K-T9540-7-BV Bath or Deck-Mount Transfer Valve trim round handle $114.75 |
|
|
Moen 3320 Rough In Moentrol Transfer Valve Ips Connection $162.06 |
|
|
Kohler Purist transfer valve trim, valve not included – K-T14491-4-CP $90.00 |
|
|
Moen 106321 Extension Kit For Transfer Valve $66.27 |
|
|
Kohler Volume Control & Transfer Valve Trim Bronze New T10184-7-BV & T10185-7-BV $50.00 |
|
|
Kohler K-T10290-4-AF Forte Transfer Valve Trim in Gold $44.04 |
|
|
Kohler K-T14491-4-CP Polished Chrome Single Handle Transfer Valve Trim $95.00 |
|
|
Kohler K-T10595-4P-CP Polished Chrome Bancroft transfer valve trim with White $93.28 |
|
|
Kohler K-T10944-4-BN Brushed Nickel Stillness transfer valve trim with lever $172.22 |
|
|
Kohler K-T10595-4-BV Brushed Bronze Bancroft transfer valve trim with metal $134.39 |
|
|
Grohe 29712000 Diverter Water Transfer Rough in Valve $161.29 |
|
|
Kohler K-T10944-4-CP Polished Chrome Stillness transfer valve trim with lever $118.37 |
|
|
Kohler K-T10595-4-BN Brushed Nickel Bancroft transfer valve trim with metal $134.39 |
|
|
Kohler K-T16242-4-CP Polished Chrome Single Handle Transfer Valve Trim $97.92 |
|
|
Kohler K-T10595-4-CP Polished Chrome Bancroft transfer valve trim with metal $93.28 |
|
|
Kohler K-T16242-4-SN Polished Nickel Single Handle Transfer Valve Trim $132.21 |
|
|
Kohler K-T10424-4V-BN Brushed Nickel Transfer Valve Trim Only with Deco Lever $156.91 |
|
|
Kohler K-T10424-4V-CP Polished Chrome Transfer Valve Trim Only with Deco Lever $108.00 |
|
|
Kohler K-T14491-4-BN Brushed Nickel Single Handle Transfer Valve Trim $137.96 |
|
|
Kohler K-408-K-NA Transfer Valve Rough In $161.88 |
|
|
Kohler K-T10290-4-BN Brushed Nickel Transfer Valve Trim Only from the Forte $118.04 |
|
|
Kohler K-409-K-NA Transfer Valve Rough In $161.88 |
|
|
Kohler K-T10424-3S-CP Polished Chrome Memoirs transfer valve trim with Stately $112.00 |
|
|
Kohler K-T10290-4-CP Polished Chrome Transfer Valve Trim Only from the Forte $81.90 |
|
|
Kohler K-T16178-4-BN Brushed Nickel Revival transfer valve trim with scroll $143.62 |
|
|
Kohler K-T18491-4-CP Polished Chrome Symbol transfer valve trim $129.68 |
|
|
Kohler K-T16242-4-BV Brushed Bronze Single Handle Transfer Valve Trim $142.25 |
|
|
Kohler K-T16242-4-BN Brushed Nickel Single Handle Transfer Valve Trim $142.25 |
|
|
Kohler K-T13175-3A-CP Polished Chrome Single Handle Transfer Valve Trim $243.07 |
|
|
Moen T4171 Chrome Tub and Shower Transfer Valve Trim $52.80 |
|
|
Kohler K-T16242-3-BN Brushed Nickel Single Handle Transfer Valve Trim $142.25 |
|
|
Moen T4171BN Brushed Nickel Tub and Shower Transfer Valve Trim $72.32 |
|
|
Kohler K-T10185-7-CP Polished Chrome Mastershower Transfer Valve Trim $71.66 |
|
|
Kohler K-T16242-3-CP Polished Chrome Single Handle Transfer Valve Trim $97.92 |
|
|
Kohler K-728-K-NA Mastershower 2- or 3-way Transfer Valve – Replaces Kohler $117.75 |
|
|
K-T12189-4-BV Kohler Fairfax Transfer Valve Trim $75.00 |
|
|
Grohe Seabury/Geneva 29712 000 tub shower diverter transfer valve $255 list $139.00 |
|
|
Moen Monticello Three Function Transfer Valve Trim Vertical Spa Set 243CP $281.99 |
|
|
Kohler K-728-K-NA Mastershower Transfer Valve $106.88 |
|
|
Moen 106321 Three Function Transfer Valve Extension Kit $54.95 |
|
|
2 Way 1/2″ Tub Bathroom Shower Diverter Transfer Valve Faucet Oil Rubbed Bronze $74.98 |
|
|
Kohler IV Georges Brass transfer valve trim K-T10682-4-BN $288.00 |
|
|
KOHLER K-728-K MASTERSHOWER TWO 2 OR THREE 3 WAY 3/4″ inch TRANSFER VALVE $119.99 |
|
|
Kohler K-T10595-4-BN Transfer Valve Trim Brushed Nickel $140.59 |
|
|
K-9530-BV Kohler 2-Way Deck Mount Transfer Valve $170.00 |
|
|
Kohler K-T10944-4-CP Stillness Polished CHROME Transfer Valve Trim Lever Handle $95.00 |
|
|
DELTA T11640 Single Handle Six Setting Transfer Valve Chrome $48.99 |
|
|
Kohler Bancroft® transfer valve trim T10595-4-AF $55.20 |
|
|
Moen Kingsley Moentrol Three Function Spa Set Trim and Transfer Valve 263CP $276.99 |
|
|
Kohler K-T13175-4A-SN Polished Nickel Single Handle Transfer Valve Trim $328.02 |
|
|
Kohler K-T10595-4-AF French Gold Bancroft transfer valve trim with metal lever $125.81 |
|
|
Grohe 29 714 000 Diverter&Transfer 5-Port RoughIn Valve $172.25 |
|
|
Kohler K-T376-4-BV Transfer Valve Trim Kit Bronze $116.04 |
|
|
Kohler K-T10944-4-CP Transfer Valve Trim Chrome $123.83 |
|
|
3-Way Transfer Valve , SV33 $72.99 |
|
|
Moen Three Function Commercial Transfer Valve Trim 8360 $121.63 |
|
|
Speakman S-1182 Chrome Two Way Transfer Valve with Brass Handle and Brass $81.20 |
|
|
Kohler K-407-K-NA Wall-Mount 3-Way Transfer Valve $114.95 |
|
|
Kohler T-9474-4-PB Master Shower Trim Kit for 3-way Transfer Valve $49.99 |
|
|
One Handle Transfer Valve Trim $170.44 |
|
|
MOEN SHOWHOUSE S542ORB FELICITY EXACTTEMP W/FIVE FUNCTION TRANSFER VALVE SPA SET $1,200.00 |
|
|
GROHE Diverter/Transfer Valve Trim 19 903 ROO Polished Brass $39.99 |
|
|
Kohler K-693-K Hi-Flow Valve and 3 Way Transfer Valve $358.48 |
|
|
Moen 3330 M-PACT 1/2-Inch CC Transfer Valve $99.99 Moentrol® pressure-balancing valves deliver perfect water coverage, force and flow and have temperature memory to prevent hot and cold surges…. |
|
|
KOHLER K-T10944-4-CP Stillness Transfer Valve Trim, Polished Chrome $112.00 Finish/Color:Polished Chrome Streamlined elements and understated sophistication are the essence of Stillness faucets. Paired with a 3-way transfer valve, this Stillness 3-way transfer valve trim allows you to choose from six different outputs and direct the water exactly where you want it. Its pared-down approach to design is an ideal accompaniment to contemporary showering environments. Patent… |
|
|
… |
|
|
The 2009 Report on Solenoid-Operated Valves and Parts Excluding Nuclear and Fluid-Power-Transfer Valves: World Market Segmentation by City $795.00 This report was created for global strategic planners who cannot be content with traditional methods of segmenting world markets. With the advent of a “borderless world”, cities become a more important criteria in prioritizing markets, as opposed to regions, continents, or countries. This report covers the top 2000 cities in over 200 countries. It does so by reporting the estimated market size (in… |
|
|
The 2009-2014 World Outlook for Solenoid-Operated Valves and Parts Excluding Nuclear and Fluid-Power-Transfer Valves $795.00 This econometric study covers the world outlook for solenoid-operated valves and parts excluding nuclear and fluid-power-transfer valves across more than 200 countries. For each year reported, estimates are given for the latent demand, or potential industry earnings (P.I.E.), for the country in question (in millions of U.S. dollars), the percent share the country is of the region and of the globe…. |
|
|
The 2011-2016 World Outlook for Solenoid-Operated Valves and Parts Excluding Nuclear and Fluid-Power-Transfer Valves $795.00 This econometric study covers the world outlook for solenoid-operated valves and parts excluding nuclear and fluid-power-transfer valves across more than 200 countries. For each year reported, estimates are given for the latent demand, or potential industry earnings (P.I.E.), for the country in question (in millions of U.S. dollars), the percent share the country is of the region and of the globe…. |
|
|
Triple Seven Safety Siphon Self Priming Pump $8.39 Triple Seven Safety Siphon Self Priming Pump…. |
|
|
Lumax LX-1344 Black Hand Transfer Pump $21.35 The hand transfer pump is ideal for transferring fluids from one container to the other and for draining oils and other fluids. The easy pumping action allows smooth transfer of non-corrosive fluids, such as, motor and hydraulic oil, transmission fluid, brake fluid, cleaning fluids, agricultural and industrial chemicals. It is ideal for automotive, commercial, industrial and agricultural applicati… |
|
|
SHURflo 4008-101-E65 3.0 Revolution Water Pump $69.95 SHURflo’s New Revolution™ fresh water pump design was created with a unique one-piece diaphragm and internal by-pass, assuring long life and top performance in all plumbing systems. Designed as the next legendary pump to exceed the expectations of our customers, the Revolution™ Pump is built for high flow demand, low noise and no rapid cycling. SHURflo’s quality reputation has been built o… |
|
|
Moen T4171BN 3-Function Transfer Valve Trim Kit without Valve, Brushed Nickel $64.39 Finish:Brushed Nickel From finishes that are guaranteed to last a lifetime, to faucets that perfectly balance your water pressure, Moen sets the standard for exceptional beauty and reliable, innovative design. Available in a Chrome, Brushed Nickel or Oil Rubbed Bronze finish Lever design for ease of use Transfer Limited lifetime warranty… |
This entry was posted on Saturday, April 1st, 2006 at 11:23 am and is filed under Uncategorized. You can follow any responses to this entry through the RSS 2.0 feed. You can leave a response, or trackback from your own site.